How is fork oil capacity measured?
The proper way to measure fork oil is take the springs out, collapse the forks all the way down, then measure how far the oil is down from the top of the fork. If you don’t have a manual, check with your dealer for the correct level down. I run my fork oil 130mm down from the top.
What happens if you overfill fork oil?
If it’s really over filled, then the forks become rock hard and the springs that are in the forks are more or less there for the ride as the “air spring” which is the air volume above the fluid level begins to dominate everything. So, if your forks are overly stiff, yes, too high oil level might do that.
How do I know if my forks need oil?
Registered. Some indicators for basic bath oil/seal service = leaking around seals, excessive oily dirt goo build up on top of seals that reappears on every ride, visible wear on stanchions(by that time it’s too late).
What is the difference between fork oil and shock oil?
Fork oil and shock oil make up the suspension fluid but do not consist of the same thing. Fork oil obviously goes in the forks and has a different viscosity than the shock oil which lubricates the shock located beneath the seat below the subframe.
Can you overfill motorcycle forks?
yes overfilling makes it feel like there is very little bounce in it. checking oil level can be done without removing the forks off the bike, but best with bike’s weight of the wheel : use a lift or jack if available.
Can I change fork oil without removing forks?
You will need to remove the caps to refill the fork tubes with oil. Determine if the fork legs have oil drain plugs near the bottom of the legs. If they do, you are in luck and will be able to change the oil without removing the fork legs.
How often should you change your fork oil?
A good cleaning and new fork oil and you are good to go for some time. I change mine every two years or whenever a fork seal leaks. That usually ends up being about once every two years. I also ride my road bike around 15,000 to 20,000 miles a year.
What kind of tires does a Yamaha XJ 700 have?
On the topic of chassis characteristics, responsible for road holding, handling behavior and ride comfort, the Yamaha XJ 700 S Maxim has a Tubular steel, double cradle frame with front suspension being Telescopic fork and at the rear, it is equipped with Swingarm . Stock tire sizes are 100/90-19 57H on the front, and 130/90-16 67H on the rear.
What kind of oil does a Harley Davidson Fork take?
I Am Replacing My Front Fork Springs With Progressive On 2000 Vulcan 1500v Clic The Owners Manual Does
How often should I change my fork oil?
Changing Fork Oil! One of the more neglected fluids is the fork oil. It just sits there going up and down as the road goes by but it also gets dirty and loses some of it’s finer properties as time goes by I change my fork oil every 5 to 7 thousand miles.
How do you change oil on a virago Fork?
Loosen the 10mm fork brace clamp nuts at the top of the fork and bleed the air out of the fork tubes if applicable. Using the 17mm allen wrench, the 17mm bolt, or 3/8″ bolt (slightly filed down to fit the fork cap) and clamped with vise grips unscrew the fork cap. It may not break free easily.