What to do if Honda Express battery blows?
Check the fuse in the little casing. If it is blown, replace it. once all this has been done, put the seat back on. The 1977 and 1979-1980 express used one type of battery. The 1978 used a different type. The 1981+ used a third larger type. Make sure to get the right one for your bike should you need a new one. Pull out the spark plug.
What kind of timing cover does a Honda Express use?
The 1977 uses an NGK BP6HS. The 1978 and later uses an NGK BP5HS. The UK 1978 and later uses an NGK BPR4HS. Pull the timing cover off (the round shiny metal cover on the right hand side of the motor with HONDA written on it). turn the flywheel until you can see the points (the two metal “Fingers” that open and close as the flywheel turns.
Why does my car make noise when I go over 20 mph?
If you hear the noise above 20 mph it’s most likely a wheel bearing noise but it’s not a bad idea to check the tire tread to be sure the tires are not chopped or worn uneven. If you what to leave me more details about the noise I may have a more definitive answer to what may be the problem.
How to troubleshoot a car exhaust or engine noise?
How to Troubleshoot a Car Exhaust or Engine Noise 1 Understanding the common noises associated with engine or exhaust component failure. 2 Whirring. 3 Hissing, gurgling, or sizzling. 4 Loud exhaust. 5 Backfiring. 6 Sputtering. 7 Tapping, clicking, or knocking. …
What makes the Honda check engine light work?
All Honda fuel caps have a ratcheting device built into the cap to achieve a good seal and keep you from over-tightening the cap. When tightening your fuel cap, be sure to turn it enough to hear at least three clicks; that ensures the proper torque was applied.
If you hear the noise above 20 mph it’s most likely a wheel bearing noise but it’s not a bad idea to check the tire tread to be sure the tires are not chopped or worn uneven. If you what to leave me more details about the noise I may have a more definitive answer to what may be the problem.
How to Troubleshoot a Car Exhaust or Engine Noise 1 Understanding the common noises associated with engine or exhaust component failure. 2 Whirring. 3 Hissing, gurgling, or sizzling. 4 Loud exhaust. 5 Backfiring. 6 Sputtering. 7 Tapping, clicking, or knocking.
What causes a water leak in the back of a Honda?
If the water is only visible on the rear carpet, the leak may be in the rear of the vehicle. The most common cause of a water leak is the windshield; sometimes a newly replaced windshield will leak.
When does the ignition warning light not come on?
If your car is fitted with an alternator the warning light should not come on when the engine is idling, provided the idle setting is correct, because an alternator produces current even at low speeds.
What kind of plug does a Honda Express use?
If so keep going, if not you either have a bad cable, bad coil or bad points. It would be a good idea to put in a new plug if the one you have is worn or the wrong type. The 1977 uses an NGK BP6HS. The 1978 and later uses an NGK BP5HS. The UK 1978 and later uses an NGK BPR4HS.
What kind of battery does Honda Express use?
The 1977 and 1979-1980 express used one type of battery. The 1978 used a different type. The 1981+ used a third larger type. Make sure to get the right one for your bike should you need a new one. Pull out the spark plug. Clean it off. Set the gap to about 0.026 inches (about 0.65 MM).
Why are there no lights on my Honda ATV?
Another odd thing is when I would turn on the key it would take a 10-15 seconds for the neutral light to come on and sometimes it would be very dim. It almost acts like loose connection or a switch that’s not operating correctly, but I have been unable to find either.
Are there lights on the dash of a Honda?
I still have no lights on the dash nor does the starter button engage the start. Battery is good and I can short across the starter solenoid and it spins the starter. I forgot to mention earlier that I installed an aftermarket key switch 2 years ago.
Where does the ignition warning light come from?
The wire runs from the alternator through the bulkhead and up to the warning light mounted in the dashboard. From here it runs to the ignition/starter switch. In general, if the charging system is working normally, the warning light should glow when the ignition is switched on and then extinguish when the engine is started.
Check the fuse in the little casing. If it is blown, replace it. once all this has been done, put the seat back on. The 1977 and 1979-1980 express used one type of battery. The 1978 used a different type. The 1981+ used a third larger type. Make sure to get the right one for your bike should you need a new one. Pull out the spark plug.