What kind of fuel injection does a Volvo 240 have?

What kind of fuel injection does a Volvo 240 have?

For owners of 1982-89 non-turbo Volvo 240 series, Volvos with LH fuel injection. Here’s a chance to put an end to intermittent electrical problems with our watertight fuse holder system. With the Bosch® LH fuel injection system, current is supplied from the battery to an exposed blade style fuse.

Where is the fuel pump hose on a Volvo 240?

240 models with Bosch LH electronic fuel injection have a large plastic accordion style intake hose that connects the air mass meter to the intake manifold. This hose rests on the inner fender, over time a hole will wear through where it touches.

Are there any problems with the Volvo 240?

It commonly fails in the open position allowing super heated air to be drawn into the engine, which reduces performance as well as dramatically shortening the life of the expensive air mass meter. The seats in the 240 are very comfortable when they are in good condition. 240 seats offer excellent adjustable lumbar back support.

What kind of trans fluid does a Volvo 240 use?

Often replacing the lightweight Type F auto trans fluid used in them with a 30-50 weight will provide a few more years of service. The Volvo 240 goes through engine and transmission mounts on a regular basis! To prevent serious damage you’ll need to inspect them annually.

Why did Volvo stop using DL and GLE labels?

It added a feedback loop to the K-Jetronic fuel injection system already in use, which allowed fine-tuning of the air and fuel mixture and therefore produced superior emissions, drivability and fuel economy. For the 1983 model year, Volvo dropped the DL and GLE labels, selling the cars simply as 240s.

When did the Volvo 240 DL Jubileum come out?

240 DL Jubileum (1987): Volvo released this model to celebrate its sixtieth anniversary. Like the fiftieth anniversary edition, it was based on the 240 DL series, only this time it was available as both a saloon and an estate.

What kind of electrical system does a Volvo 240 have?

Volvo 240 with B23F (can also be used for B23E) LH Jetronic system fault tracing (1983 and later models) This group contains the electrical components of the Volvo 240 and 260.

When did the Volvo 240 go out of production?

Even though the Volvo 240 has been out of production since 1993, it is still a popular car among Volvo enthusiasts and a favorite among our staff. Over the past 40 years since it was introduced, we have come to know quite a bit about the iconic model.

What kind of service does a Volvo 240 need?

Volvo 240 & 260 CIS (constant idle speed) servicing, repair, wiring diagrams & fault tracing 1981+ models Volvo 240 with B23F (can also be used for B23E) LH Jetronic system fault tracing (1983 and later models) This group contains the electrical components of the Volvo 240 and 260.

What to do if your Volvo 240 wont start?

Prevent numerous problems associated with the fuse box, by pulling all fuses and cleaning them annually. If you encounter a intermittent or no start issue on your Volvo 240, you can often get going again by simply spinning the fuses in their holders, which reestablishes electrical contact.

Which is better Bosch or Volvo fuel injection?

Possibly in theory Volvos system is better, but in reality it gets overlooked and inevitably becomes clogged up and causes oil leaks and idle problems. Volvo 240 models with Bosch LH electronic fuel injection have a large plastic accordion style intake hose that connects the air mass meter to the intake manifold.

What kind of gasket does a Volvo use?

This is the same flange Volvo uses, but they use a raised lip on the exhaust manifold and recess in the turbine housing to make a mechanical gasket-less seal. This lip on the manifold must be machined down by a mill in order to use one of these turbos.

What causes an injector to fail in a car?

Typically, when injectors fail, the solenoids often short internally, causing a drop in resistance. If the specification calls for 3 ohms and an injector measures only 1 ohm; it will pull more current. Too much current flow to an injector; may cause the (PCM) injector driver circuit to shut down.

What kind of car is Volvo 240 DL?

Volvo 240 DL 1989, 5-speed manual Harrisburg, AR 17754, USA Volvo 240 DL 1989, 5-speed manual transmission, 304,000 miles, runs very well. New Mexico car – some minor sun damage but no rust, well-maintained single-owner car.

How long has the Volvo 240 been out of production?

Even though the 240 has been out of production for almost 17 years, it is still a popular car among Volvo enthusiasts and a favorite among our staff. Over the past 35 years since it was introduced, we have come to know quite a bit about the iconic model.

What causes a Volvo 240 to overheat?

This is usually caused by a failed pre pump in the gas tank, which in turn causes the main fuel pump to be overworked and draw excessive amperage that overheats the circuit.You can confirm this failure by popping the cover off the relay and inspecting the solder joints on the circuit board.

Can a 16 gallon tank fit on the left hand side?

All tanks fit Left Hand or Right Hand side. Some longbed trucks were equipped with 16 gallon tanks, check yours before ordering. QTY. “A” One kit mounts LH or RH gas tank supports. “A” One kit mounts LH or RH gas tank supports. “B” Universal valve with single wire connector. “B” Universal valve with single wire connector.

Why are the fuses on my Volvo 240 not working?

Second, the small contact area of the European ceramic style fuses also leads to corrosion due to electrolosis. Prevent numerous problems associated with the fuse box, by pulling all fuses and cleaning them annually.

Is there a service manual for a Volvo 245?

Volvo 245 (5-door estate / stationwagon with 4-cylinder redblock or 6-cylinder diesel engine) Using the Volvo service manual isn’t hard: just look for the subject described below (like the engine, bodywork or cooling system) and click on the link to open the service manual for that subject.