How do you check flow injectors?
Ohm testing: A simple test to verify the condition of the injector coil, we test the resistance (measured in Ohms) across the terminals of the injector connector. Spray pattern verification: During the flow test, our techs evaluate the spray pattern of your injectors.
Which is GM Duramax LLY fuel injector do you use?
The BD-Power 1715504 Remanufactured Fuel Injector for your 2004.5-2005 GM 6.6L Duramax LLY is a direct replacement for your factory injector. BD-Power is one of only a few shops with the capability, the know-how and equipment to fully test and rebuild common rail injectors.
What’s the balance rate on a fuel injector?
Balance rates are nothing more than how far off of the average fuel flow each injector is.
Why is LB7 injector failure a common problem?
We know today LB7 injector failure is a common problem, and because the operating tolerances inside the fuel system are so tight, proper lubrication from the diesel fuel is critical.
How is return rate of Duramax injector determined?
Return rates is the amount of fuel each injector returns to the tank during a 15 second cranking cycle, and involves a test set with 4 graduated cylinders to perform as well as some engine teardown to perform it. return rates are a much more accurate test of injector health since 01-10 DURAMAX injectors are a pressure differential valve.
The BD-Power 1715504 Remanufactured Fuel Injector for your 2004.5-2005 GM 6.6L Duramax LLY is a direct replacement for your factory injector. BD-Power is one of only a few shops with the capability, the know-how and equipment to fully test and rebuild common rail injectors.
What are the symptoms of a leaking fuel injector?
Symptoms of leaking fuel injectors: 1 Hard Starting when engine is hot. 2 Increased Fuel Consumption. 3 Rough Idle. 4 Fuel odors inside and around the car. 5 Poor Emissions. 6 (more items)
Can a fuel injector be tested under pressure?
Fuel injector leak testing should be done under operating pressure. The average DIY fuel injector cleaning project and most automotive repair shops does not have the proper diagnostic equipment or the ability to test leaking injectors or clean them properly.
How much does a Duramax fuel injection set cost?
LLY 2004.5-2005 Chevy/GMC Duramax 6.6l Diesel Injector Set (New Nozzles) $1,920.00. LLY 2004.5-2005 Chevy/GMC Duramax 6.6l Diesel Injector (New Nozzle) $240.00. LLY 2004.5-2005 Duramax Diesel Fuel Injection Control Module (FICM) $1,775.00. Sold Out. 2004-2010 GMC/CHEVY ROCKER BOX & VALVE COVER GASKET.