How do you replace a fuel tank in a Volvo?
To replace one, you’ll have to drop the fuel tank for access to the other end of the metal fuel line. Rust may require that you buy new fittings as well on that end.
Can a PCV box be replaced on a Volvo S60?
Here’s a nice write up for 1999+ Volvo 5-cylinder PCV System courtesy of Matthews Volvo Site. Check out the video below of a full PCV replacement on a Volvo S60. The procedure is very similar to many other models. Volvo S60 PCV Breather System Replacement – Prevent Smog! (C70, S60, S80, V70, XC70, XC90)
What kind of clamps do I need for a Volvo fuel tank pump?
The large clamp holding the fill hose is Volvo p/n 943477-0; buy two of these. The smaller clamps are 943471-3; buy four of these. The spring clamps are 1321719-5; buy one of these unless you want to replace it with a screw clamp (recommended).
How long does Volvo 940 fuel tank pump last?
Measuring the fuel pressure at the rail, crudely with a tire gauge, the same effect was seen – sometimes 25-30 lbs, other times about 5 lbs. This exercise is shown on a ’92 940 with 142K miles. The in-tank pumps seem to last perhaps 150k miles. Note similarities between the two tank pumps on the left:
What do you need to know about fuel pump lock rings?
This socket has been designed to remove and install the left and right fuel pump retaining nuts (also called lock rings) on all late model Volvos without dropping the fuel tank. The retaining nut can be locked in place requiring a fair amount of force to release and the plastic retaining nuts are easily broken when improper tools are used.
Where is the fuel tank sender on a Volvo?
Be careful you do not damage the electrical wires: Then disconnect filler hose: To remove the Volvo quick disconnect fitting on the fuel outlet line (the 90-degree fitting below), grip the outer sleeve, and push that outer plastic cylindrical sleeve towards the top of the fuel tank send unit.
Where is the fuel pump located on a Volvo?
2 – Two relays on B23 (1983-84) LH-jet, one for main system and one for fuel pump. 3 – Not for 1988 and later 760 turbos or V6 models or 1991 SE models. The pre pump is a low-pressure, high-volume pump that sits inside the gas tank and supplies fuel to the main high pressure pump under the car.
What kind of tank does a Volvo 240 have?
Volvo 240, a bulletproof tank. I had an 84 244DL, when I sold it to the neice of a friend it was running strong with original 350,000 miles. I replaced the alternator twice and the starter once.
When was the last recall on a Volvo?
Volvo Recall Information is available from August 1999. For recalls prior to this date, please contact us by using our Volvo Customer Care Contact Us form or call us at 1-800-458-1552 for possible additional recall information.
How long does a Volvo fuel tank pump last?
When it sank to 1A the idling car would die. Measuring the fuel pressure at the rail, crudely with a tire gauge, the same effect was seen – sometimes 25-30 lbs, other times about 5 lbs. This exercise is shown on a ’92 940 with 142K miles. The in-tank pumps seem to last perhaps 150k miles.