When to replace the thermostat on a Volvo S60?
He mentioned having removed the thermostat hose. This short video presents step by step a way to replace the thermostat in Volvo models from around 2003 to 2007 (S60 and V70 with the 2.4 non turbo engine). The replacement part used in this video is a Beck/Arnley #143-0850 about $100 off Ebay.
Where is the coolant reservoir on a Volvo 850?
Remove the big black plastic radiator splash guard (one bolt on each side, 10mm I believe) under the radiator. Remove the cap on the coolant reservoir, then place the bucket under the plastic radiator drain valve. This can be found on the driver’s side, bottom edge of the radiator.
How does the thermostat work in an engine?
The thermostat acts as a valve that stays closed during engine warm-up. When the thermostat is closed, it prevents coolant from leaving the engine and circulating through the radiator. When the engine gets warm, the thermostat’s spring valve opens, allowing coolant to circulate through the radiator to be cooled.
Where is the coolant drain valve on a Volvo?
Remove the cap on the coolant reservoir, then place the bucket under the plastic radiator drain valve. This can be found on the driver’s side, bottom edge of the radiator. Drain about two liters of coolant into the bucket, then tighten the valve back up. Be very careful with this valve … it’s plastic and they have been known to break easily.
Is there a problem with my Volvo cooling system?
Dexcool is known to have problems with high-lead solders, and is also sensitive to air levels in cooling systems. If you don’t keep the system topped off to the “min” mark on the reservoir, it may cause scaling and rust precipitation. The last Glysantin alternative is new in the US, although well-known in Europe,…
What kind of radiator is used in a Volvo?
[Motor Magazine, Aug 2004] One of the coolant issues that may arise is the use of an aftermarket replacement radiator or heater core made of copper-brass with lead solder.
How often should I change the coolant in my Volvo?
[Ywan Mason] Dex-Cool, according to a GM service bulletin only gives the extended life when it was used as the first and only coolant in the car. Residual amounts of conventional coolants left in the system even after careful draining require that the Dex-Cool be changed at the same interval as any other coolant, every two years.
What kind of parts does a Volvo S60 have?
Models 2001 – 2003 2.4T 2001 – 2016 T5 2002 – 2003 AWD 2004 – 2009 2.5T 2004 – 2005 2.5T AWD
When did the Volvo S60 get an update?
In 2004, updates were made to the Volvo S60. Among those changes was a rounder shape for the front of the vehicle, including a new bumper and a new grille. In addition, both the rear and the front of the vehicle received new lights. A more powerful six-speed manual transmission was also introduced.
What kind of trans fluid does a Volvo S60 use?
Top parts for your Volvo S60 Auto Trans Fluid (ATF) (Type T-IV) (1 Quart) Engine Oil Drain Plug Washer (18x24x1.5mm) Exhaust Lock Nut (M8) Engine Oil Filter Cylinder Head Bolt Spark Plug (Platinum/Iridium) Valve Stem Seal