How often should the transfer case fluid be changed?
every 30,000 miles
You should have your differential and transfer case fluid checked every 30,000 miles, or when you experience any of the symptoms below. Changing these fluids is a messy job, but your local Brakes Plus team is here to help – we never mind getting our hands dirty!
What kind of oil goes in a transfer case?
The fluid level and condition can be checked through the fill plug. In most vehicles, a transfer case is filled with a small amount of gear oil (usually SAE 75W-85, 80W-90 or 75W-140 grade).
Can you service a transfer case?
The transfer case is serviced by periodically draining its fluid and replacing it with fresh fluid. We also check for leaks and damage. Transfer case fluid cools and lubricates the gears, chains, bearings, shafts and other parts. Over time, the additives in the fluid wear out and it doesn’t protect as well.
Is Front differential same as transfer case?
Depending on whether your vehicle is front-wheel drive, rear-wheel drive or four-wheel drive, the differential is on the front, rear or both axles. The transfer case acts like a differential, but channels power to the two differentials on different axles rather than to two wheels on the same axle.
How much does it cost to service a transfer case?
The average cost for transfer case replacement is between $2,500 and $2,615. Labor costs are estimated between $438 and $552 while parts are priced at $2,063. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location. Related repairs may also be needed.
How much oil do you put in a Toyota RAV4?
Get a basic fluid pump that can attach to the Gear Lub bottle. 4. Draining the fluid is very easy as long as you find the plugs (the rear axle, it’s drain is on one side with the fill on the other); the torque spec for the Drain is 29-ft/lbs (39.32-Nm), the Filler plug is 28-ft/lbs (38-Nm).
Where is the transfer case on a RAV4?
The transfer case is located to the left of the oil pan. Easy to spot since the driveshaft runs from it to the rear differential. The Fill Plug is located on the drivers side of the transfer case. It takes a 10 mm hex socket and some muscle to remove.
Where is the drain plug on a RAV4?
The Drain Plug is located on the bottom of the transfer case. It also takes a 10 mm hex socket and some muscle to remove. Break it loose by turning counter clockwise. Have your drain can ready and in place to catch old oil. Be careful not to burn yourself on the exhaust pipe: I recommend letting oil drain for at least 30 minutes.
How long does it take to change transfer case oil?
Changed the transfer case oil for the first time in the wife’s RAV4. Easy job that only took maybe 1 hr from start to finish. Can be done faster but I like to let the old oil drain for about 30 minutes.