Is the 2006 Cummin ISX a good truck?
Only egr problem I had with 3 ISX’S I drove in 4 years. I got lucky. I have an 06 isx in my 07 w900 it has 1.4 million on it but was inframed at 1.15 million no problems with the way it pulls or with fuel mileage 6.2 average.
Is there a problem with my Cummins ISM?
Discussion in ‘ Heavy Duty Diesel Truck Mechanics Forum ‘ started by TheMechanic, Dec 8, 2017 . 06 ism 320k miles. Empty loaded bobtail doesn’t matter. Surges thru all gears. As it starts to pull then power seems to be halted but the turbo continues to spool. It will do this continuously thru the entire gear up down up down.
How often does a Cummins ISX need to be replaced?
Crankcase ventilation system: The ISX’s advanced crankcase ventilation only needs replacement after every third or fourth oil change, allowing you to operate for longer. Cummins Intebrake™: The Intebrake™ can reach up to 600 braking HP, which helps control the machine and reduce brake wear.
How often does the fuel injector activate in an ISX engine?
Then, it’s distributed through the tubing to the rail system for storage under extreme pressures— about 35,000 PSI or higher. This version of the ISX relies on an engine control module (ECM) to monitor the timing and pressure. The ECM can activate each fuel injector up to five times per combustion cycle.
Where can I find the serial number of a Cummins Engine?
Clearly engine data plates contain necessary information, but sometimes they can become unreadable. Below you’ll find a list of Cummins data plate and serial number locations sure to speed identification. From the ISX Series to the 6CTA, we have them all. Visit Diesel Parts Direct to perform your Cummins engine serial number lookup.
What does the ISX stand for in diesel engine?
It upheld its name because it had an innovative fuel system called the “Interact System.” The “IS” in ISX stands for “Interact System.” Since its launch, the ISX has been the core of Cummins’ diesel engine fleet. Not only has it advanced with quicker processing, but it has also increased fuel efficiency since its debut.
How did my 2006 Cummins ISX engine die?
After about 5 min it died, couple gallons of coolant went through the top cap (couldn’t hold it). Towed it to some diesel shop that was right at that exit.
How many horsepower does a 2006 Volvo S40 have?
Consumer Ratings Rank Vehicles HP #2 2007 Saab 9-5 260 #3 2006 Volvo S60 257 #4 2007 Saturn Aura 224 #13 2006 Volvo S40 168
How much does a rebuilt Cummins ISX cost?
Talked to a guy that spent 20 grand to rebuild his ISX. You cannot compare a N14 to a ISX, not even the same design engine. Like Heavy D said, there is no one price because there is no telling how much damage the run away engine could have caused.
What’s the exhaust temp on a 2006 Cummins?
I have a 2006 ISX cummins 530 hp with 433,000 miles on it. It is an EGR motor. Problem is lately since weather has started to cool up motor will sometimes loss boost of about 10 lbs and exhaust temp will climb to 1000 to 1100 degrees. You might drive 5 miles and it comes out of it.
Why does my Cummins ISX low boost high exhaust temps?
If you run down south for the week, truck will no due this all week come north and it will do this all the time. 35 degrees or less and it does it. Changed out Exhaust gas pressure sensor, did not fix. Any ideas? check the turbo see if the shaft rocks enough to hit the housing also check the boost sensor see if its plugging up
Where are the vanes on a Cummins ISX?
In the 2nd video, you can see the turbine housing. The vanes on the turbine wheel fit in the slots of the rotating collar in the turbine housing at the left. If those slots fill with soot, the that collar can stick as well. Everything can be cleaned, but the dealers pretty much just replace them under warranty.
What causes a Cummins ISX to lose power?
Hazy fuel is indicative of water emulsified in the fuel. In general, dark hazy fuel will not damage your engine. It indicates however, poor fuel quality, which will definitely not provide you with peak engine performance. So what else could be causing the egr and turbo to fail.
Is there smoke or Miss in a Cummins Engine?
There is no smoke or miss in the engine. First I would check air/fuel system for a restriction, then recheck, before you suspect the turbo failed use Cummins insite program and test the turbo Changed fuel filters and test drove with same results. hooked up insite and ran turbo/egr test. egr failed with 33% change and turbo failed with 0% change.
What is on the top of a Cummins turbo?
The only thing on the top of the turbo is one line, sensor with electrical wire, and the air operated actuator. The air line to the actuator runs to the left side of the truck into a rectangular box. Would that be it? We installed another turbo on the truck and still the same problem.
Is there a 2008 Cummins ISX engine for sale?
2008 Cummins ISX used diesel engine for sale .400 HP, CPL 2732, tested and inspected with warranty. Call or visit our website for more info. Fits To: AUTOCAR, DODGE, FORD, FREIGHTLINER, INTERNATIONAL / 108SD, 114SD, 122SD, 1955, 2000, 200-33, 2110A, 220, 2200, 2275; Fits To Manufacturer: AUTOCAR, DODGE, FREIGHTLINER, INTERNATIONAL, KENWO…
Where can I buy a 2006 Cummins Engine?
2006 Cummins ISX used diesel engine for sale . 400 HP, CPL 8520 tested and inspected with warranty. Call or visit our website for more info. Sold By: BASKIN TRUCK SALES LLC.
What kind of turbocharger does Cummins ISX have?
Single overhead camshaft: Versions made after 2010 have a single camshaft system with a common rail fuel operation that relies on piston pumps to inject diesel. Variable geometry turbocharger: The turbocharger has a sliding nozzle to boost durability and reliability.
How to check if turbo or actuator is bad on Cummins ISX?
Another video just showing you how to check for your turbo or actuator being bad. Very common for both of them to be stuck, but sometimes its just one thing stuck but I always recommend still replacing both at same time. Stay tuned for how to install turbo and calibrate actuator to it video. Loading…