What are the fault codes for Detroit Diesel engines?

What are the fault codes for Detroit Diesel engines?

DETROIT DIESEL Engine Fault Codes list DTC Code Description DDEC V Circuit 11 P 187 4 Chain PTO. Short circuit in the power 11 P 187 7 control system PTO wrong answers 12 P 187 3 Chain PTO. Short circuit in the ground 13 P 111 4-level circuit antifreeze. Short circuit in the ground 13 P 111 6 second-level circuit antifreeze.

What is the SPN code for a FMI Sid?

SPN FMI PID/SID PID/SID ID FLASH CODE FAULT DESCRIPTION 634 4 SID 40 1321 Constant Throttle Valve Circuit Failed Low 634 3 SID 40 1321 Constant Throttle Valve Circuit Failed High 634 5 SID 40 1321 Constant Throttle Valve Circuit Failed Open 636 1 SID 21 1235 Crankshaft Position Sensor Signal Voltage Too Low

When did the mid code go out for Freightliner?

* On March 7, 1997. If there is no text message, the display area will be blank. Only the MID number will display. * On March 7, 1997. * On March 7, 1997. * On March 7, 1997. 154 Auxiliary IN / OUT Status # 2 AUX INP / OUTP # 2 Aux. In / Out # 2 155 Auxiliary IN / OUT status # 1 AUX IN / OUT # 1 Aux.

What is the fault code for a mid 128 engine?

Engine ECU Faults (MID 128) Fault Code Description FMI Codes MID 128 PID 26 Engine Fan Speed Percent 3,8 MID 128 PID 27 EGR Valve #1 Position Sensor 3,4,5 MID 128 PID 45 Preheater Relay Status 3,4,5 MID 128 PID 81 Particulate Filter 0,2,3,5,12

What is the fault code for an ECU?

Engine ECU Faults (MID 128) Fault Code Description FMI Codes MID 128 PPID 326 Soot Level (DPF System) 0,11 MID 128 PPID 328 Aftertreatment Injection Shutoff Valve 3,4,5,7,14 MID 128 PPID 329 Aftertreatment Fuel Injector 3,4,5,7,14 MID 128 SID 254 Engine electronic control unit (EECU) 3, 8, 12

What is the fault code for a truck?

Short circuit to battery voltage, unit injector low side. Open circuit in actuator circuit. Mechanical system does not respond correctly. Resistance too high in injector. Ground. Slow PWM Valves Solenoid Valve. Power Take-Off 1 Solenoid Valve. Power Take-Off 2 Solenoid Valve. Brake, Counter Shaft

Which is the best tool to troubleshoot a DDEC IV engine?

An essential tool to properly diagnose and troubleshoot a DDEC IV or DDEC V Series 60 EGR engine is the Detroit Diesel Diagnostic Link®(DDDL). This tool will provide you all the help you will need as it contains proper troubleshooting information for all products. NOTE:

How to troubleshoot a Detroit Diesel Series 60?

Check the air inlet and exhaust restrictions. Visually inspect the air intake and exhaust system for restrictions; if found, repair as necessary and verify repairs. If no damage is found, go to No RPM Data Received via DDDL 7.0, refer to “4.14.2 No RPM Data Received via DDDL 7.0” .

What does high fuel pressure test mean on Detroit Diesel?

If pressure is above 490 kPa (71 psi) with the engine running, refer to “4.14.4.3 High Fuel Pressure Test” , “High Fuel Pressure Test.” If pressure is between 420–490 kPa (61 -71 psi) with the engine running, refer to “12.11 Incorrect Camshaft Timing” 12.11, “Incorrect Camshaft Timing.”

What is the engine coolant sensor code in FMI?

110 2 PID 110 1212 Engine Coolant Sensor (OUT), General Temp. Plausibility Error SPN FMI PID/SID PID/SID ID FLASH CODE FAULT DESCRIPTION 132 7 PID 132 1213 Intake Air Throttle Valve Closure Detection- Positive Torque 132 14 PID 132 1213 Intake Air Throttle Valve Closure Detection -Braking Condition

How to find a Stoltz service case fault code?

Stoltz Sales & Service has spent months going through service manuals to compile one of the most complete lists of Service Case IH Fault Codes. If you can not find your Fault Code try Search All under Controller, if you still can’t find it please contact our Service Department.

When to warn Engine Lamp on DT 466E?

*- Indicates WARN ENGINE LAMP on when fault is set. That is good for 1995-1999 DT466E engines. Good Day! I’ll sticky this for you guys….

31 Engine Brake Output Open Circuit or Short to Ground 32 CEL or SEL Short to Battery or Open Circuit 33 Turbo Boost Sensor (TBS) Voltage High 34 Turbo Boost Sensor (TBS) Voltage Low 36 Oil Pressure Sensor (OPS) Voltage Low 37 Fuel Pressure Sensor (FPS) Voltage High 38 Fuel Pressure Sensor (FPS) Voltage Low 41 Timing Reference Sensor (TRS)

What causes an EOBD fault code ( DTC )?

DTCs may also be triggered by faults earlier down the line. For example, a dirty MAF sensor might be causing the car to overcompensate in its fuel-trim adjustments. As a result, oxygen sensors are likely to report fuel mixture problems.

What is a diagnostic trouble code ( DTC )?

What is a Diagnostic Trouble Code (DTC)? Diagnostic trouble codes (or fault codes) are obd2 codes that are stored by the on-board computer diagnostic system. These are stored in response to a problem found in the car by the system.

What causes a DTC to report a fault?

For example, if a DTC reports a sensor fault, replacement of the sensor is unlikely to resolve the underlying problem. The fault is most likely to be caused by the systems that the sensor is monitoring, but might even be caused by the wiring to the sensor itself.

Where is the serial number on a Detroit Diesel engine?

On the in-line engines, the model number and serial number are stamped on the right -hand side of the cylinder block in the upper rear corner. An example of a Series 4-53 serial number is 04DXXXXXXX.

Where is the Detroit Diesel diagnostic link 7.0 data link?

DDC recommends that the OEM-supplied Data Link Connector be conveniently positioned in a well protected location facilitating subsequent Detroit Diesel Diagnostic Link 7.0 (DDDL 7.0) usage (i.e., reprogramming, diagnostics, etc.).‪ Note: REQUIRED: The J1939 data link must be wired to this connector.

What does the model number 5043-5100 mean?

Model number 5043-5100 is interpreted as follows: Series 53 Engine (5), four cylinder (04), industrial, fan to flywheel (3 ), right-hand rotation with “A” accessory arrangement (5), two-valve head engine (1), and specific model Number 00 (00). Series V 53 Model Description Chart Application, Rotation and Design Variations 5 0 6 3 5 2 0 0 Series 53

Is there a power loss on a Detroit 60 series?

I have a power loss… I have a power loss on a Detroit 60 series engine its in a freightliner classic 2003.

What makes a Freightliner classic XL Detroit go out?

If you see black soot around the shaft, if you can move it in and out. What is bad about high mileage EGR Detroits is when they rack up the miles, the EGR components start going out. When you replace one EGR component, you are back in the shop replacing something else.

What kind of engine does a Detroit 14L have?

I have a Detroit 14L 515HP – Engine serial# 06R0802208. Turbo is having this loud whistling noise and turbo PSI is higher than normal when I step on it. I loose power, no signs of smoke but check engine comes on. I had this problem before but after a big hiccup, it was back to normal, now it seems to be permanent.

What is the SPN code for FMI PID / Sid flash?

SPN FMI PID/SID PID/SID ID FLASH CODE FAULT DESCRIPTION 615 4 SID 155 1615 Reserved Monitoring Unit For Temperature Diagnostics, Circuit Failed Low MU_ISP_T_TBD1_SRL 615 3 SID 155 1615 Reserved Monitoring Unit For Temperature Diagnostics, Circuit Failed High MU_ISP_T_TBD1_SRH 615 4 SID 155 1615

What’s the short circuit in a Detroit Diesel truck?

Short circuit in the power 15 P 52 4 circuit coolant temperature intercooler. Short circuit in the ground 15 P 110 4 circuit temperature antifreeze. Short circuit in the ground 15 P 175 4 Chain oil temperature.

What does DTC stand for in OBD system?

DTC Meaning: What is a DTC code? Let’s start by explaining the DTC meaning first. DTC stands for Diagnostic Trouble Codes. A DTC code is a series of diagnostic trouble codes used by a vehicle’s onboard diagnostics (OBD) system to alert you when a vehicle experiences a malfunction.

How does Detroit Diesel Series 60 engine work?

Detroit Diesel Electronic Controlled Series 60 engines can be equipped with a variety of options designed to warn the operator of an engine malfunction. The options can range from “Check Engine” and “Stop Engine” panel lights to automatic reduction in engine power followed by automatic engine shutdown.

Where is the serial number on a Detroit Diesel?

1 ENGINE MODEL AND SERIAL NUMBER DESIGNATION The engine serial number and model number are stamped on the cylinder block in the following location (as viewed from the flywheel end): Left side just below the intake manifold and above the cast-in Detroit Diesel logo. Location of Engine Serial and Model Numbers 2 DDEC II

Posted In Q&A