What to do if your blower fan stops working?

Table of Contents

What to do if your blower fan stops working?

Take glove box out on passenger side. Upper left corner is Blower Fan Knock on it. If it comes on it is going out will need to replace. Blower fan will not come on at all? Check Fuses & Blower Fan? Fuses replaced for blower fan,took blower fan out and tested it and it worked? Well it has to be you climate control panel nothing else to check!

Why is air not blowing out of the dash vents?

A few different items can cause the air to not blow out of the dash vents. The most common are a blend door or a control switch.

Why does AC stop blowing out the defrost vents?

After installing a new blower fan motor the ac would only come out the defrost vents. The factory vacuum check valve is very hard to get to. So i bypassed it. Now it is working like it should and ac comes out the dash vents. I do not have a vacuum reservoir installed i will have to see if i will need to add it later.

Why is my a / C blower not blowing?

A metal that when it corrodes, it turns white, and unlike copper, aluminum corrosion does not conduct electricity at all and causes resistance issues and can cause overheating of a circuit. Took out a common finger nail Emory board and went to work, both sides of each contact, then used a small brass brush on each side and along the tips.

Take glove box out on passenger side. Upper left corner is Blower Fan Knock on it. If it comes on it is going out will need to replace. Blower fan will not come on at all? Check Fuses & Blower Fan? Fuses replaced for blower fan,took blower fan out and tested it and it worked? Well it has to be you climate control panel nothing else to check!

How do I stop no air from dashboard vents?

This door is controlled by a thumb wheel that when activated will open and close the vent air flow door. Work the thumb wheel from one side to the other while checking the airflow. The flow should stop and start again, if the thumb wheel does not make a difference the problem is somewhere else.

What happens when a car fan is not working?

That means a trickle out of your vents instead of the rush you asked for. When it does happen, you’re left with a miserably underpowered heat or AC system. It will still work with no fan, and you’ll usually still be able to control the temperature of the air that is blowing or trickling, out.

Why does my a / C front blower stop working?

No matter how many times (or position) the fan speed knob is moved, the front blower motor fails to respond. A/C system can be turned off and on multiple times, but the front blower fails to respond.

If you have checked the resistor,the relay fuse, the regular fuses, the switches, and the blower fan motor and none of that works try replacing your thermostat. It’s not an expensive or tedious task but that is what worked for me.

What causes a fuse to blow on a blower motor?

If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current from a bad relay will blow the fuse and cut power in order to protect the system.

What causes a bad or failing blower motor relay?

Blown fuses. One of the first symptoms of a bad or failing AC blower motor relay is a blown AC blower motor relay circuit fuse. If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current…

What happens if you have a bad blower motor?

The blower motor is the component responsible for pushing air through the vents of your vehicle’s heating and air conditioning systems. Without it, the AC system will not be able to circulate any heated or cooled air.

If you have checked the resistor,the relay fuse, the regular fuses, the switches, and the blower fan motor and none of that works try replacing your thermostat. It’s not an expensive or tedious task but that is what worked for me.

What happens when a blower resistor goes bad?

Like on mine, the lowest fan speed no longer works, but the rest do. That’s the blower resistor. When that goes bad the highest speed will still work because the current goes directly to the blower motor, not through the resistor. …my blower resistor went bad last summer.

What happens when the lowest fan speed stops working?

Like on mine, the lowest fan speed no longer works, but the rest do. That’s the blower resistor. When that goes bad the highest speed will still work because the current goes directly to the blower motor, not through the resistor.

What to do if your AC or heater is not blowing?

If your Blower Motor for the AC or Heater suddenly stopped blowing, look here first, it might save you several dollars. Situation, we have a friend that owns a 2017 Chevy Trax LT, she is a nurse who works with my wife, single mom and on a single mom budget.

No matter how many times (or position) the fan speed knob is moved, the front blower motor fails to respond. A/C system can be turned off and on multiple times, but the front blower fails to respond.

Why is my AC fan not turning off?

The main culprit may be the control board or your thermostat is faulty. On some air conditioners the speed settings do not allow the fan or compressor to shut off. To get those turned off, you have to switch your setting to automatic. If your have already set your control to automatic then the problem is probably in the control board or thermostat.

Is the front blower on my win still working?

It’s been about six weeks since we replaced the WIN. To clarify, the rear blower always works. The front blower will come on and, if its going to quit, it will cycle off, back on and then off until I restart the van. It has quit at every speed-no one speed more than any other.

Why does my AC fan keep failing to start?

If you leave the unit running, the fan motor will keep attempting and failing to start. The capacitor may also be used to keep the fan motor running properly as well as starting it.

It’s been about six weeks since we replaced the WIN. To clarify, the rear blower always works. The front blower will come on and, if its going to quit, it will cycle off, back on and then off until I restart the van. It has quit at every speed-no one speed more than any other.

When to replace a blown fuse on a C300?

If you need to replace a blown fuse in your C300, make sure you replace it with one that has the same amperage as the blown fuse. If checking and replacing the fuse for the component in question doesn’t work, we recommend seeking assistance from a trusted professional mechanic.

Why does my Mercedes Benz blower stop working?

Im from Malaysia… i just want to ask why my blower stop working after i charge the gas in the system. like it suddenly stop. is it because its a burden to the blower? and..the compressor didnt stop eventhough i released all the gas. maybe there’s problem at the controller. but whats the reason this happen? sorry my english kinda suck. Hi.

Is the fuse on the blower motor okay?

The blower motor fuse is fine (the one on the driver side shock tower, right?). This blower motor problem has been discussed quite a few times, and you should be able to find solutions by searching these discussions. Look in the “stickies” at the top of the forum, DIY repairs. :nerd

Where is the blower motor in a Mercedes Benz?

With the tab pulled down turn the motor clockwise and wiggle and pull it down and out of the housing. With the motor out of the vehicle you can better see the tab you will be gently pulling down on (red arrow). The housing goes up to the air box in the engine compartment (red arrow).

Why does my air conditioner blower make a whining sound?

The blower motor and resistor move the air through the HVAC system. If you are starting to hear a whining sound when the motor is running or the motor doesn’t run at all there is a good chance that the motor is going bad.

What to do if your blower motor stops working?

Personally, I replaced mine when it stopped working and that solved the problem. There is a motor and relay below the motor that many folks replace at the same time, since both are known to fail. One form member even has an excellent write up about the replacement, including pics.

The blower motor fuse is fine (the one on the driver side shock tower, right?). This blower motor problem has been discussed quite a few times, and you should be able to find solutions by searching these discussions. Look in the “stickies” at the top of the forum, DIY repairs. :nerd

Why does my air conditioner blower not work?

We’ve got a little extra weirdness going on in this one ’92 s10. The blower will work, but only after tapping on the resistor/relay/fan speed switch. Changing the fan speed or turning the blower on or off will cause it to fail again until you give the relay another good tap or two.

Why does my Chevy S-10 heater fan stop working?

If this system is wired as a simple circuit and has a ground side resistor to provide speed changes, that’s how it reduces the current flow. when using “hi blower” the resistance would be in the melted connector you found. If this system is controlled by a more complex climate control it may be scanned or self tested.

How to replace a blower resistor and motor?

Easy video on how to replace blower resistor and motor with 1 screw driver and in about 10min. Remove glove box, pop bottom panel off to gain motor access. Disconnect cables to motor and resistor. Remove hose from motor, it should just pull off with little effort. Unscrew motor and resistor. Screw new motor and resistor in. Connect hose to motor.

When to replace AC fan speed resistor 98-04?

Buy Now! When your blower motor for the AC and heat isnt working on all settings then chances are your blower motor resistor has failed. This is usually do to moisture from the cabin air box corroding the electrical component. Here we’ll show you how to repair it and if you’re in need of a new one, check out 1AAuto.com.

Why is my AC blower motor not working?

When your blower motor for the AC and heat isnt working on all settings then chances are your blower motor resistor has failed. This is usually do to moisture from the cabin air box corroding the electrical component. Here we’ll show you how to repair it and if you’re in need of a new one, check out 1AAuto.com.

What causes a blower motor to stop running?

Most blower motors ground through the case of the motor when it is screwed into place or by a small ground strap from the case to the body of the car. Over time, the ground connection can become corroded or loose, causing the motor to function intermittently. Lee Sallings is a freelance writer from Fort Worth, Texas.

How can I tell if my blower speed switch is faulty?

Test for power at all the blower speeds by moving the blower speed switch through all positions. A faulty resistor loses power at different positions on the switch. High blower speed has direct power to the motor from the switch. If there is no power indicated on high blower speed, the problem is most likely the switch or the fuse.

How do you troubleshoot a blower motor resistor?

This can be annoying, but troubleshooting is easy. If you start at the blower motor, and check resistance in the circuit, you will find the problem in no time. Power supplied from the fuse panel passes through the switch to the blower resistor assembly.

Why does my 2000 Xterra air conditioner not work?

The 2000 Xterra’s Air Conditioning is sometimes cool but may not work other times. The Air Conditioning System will get cold when the Compressor Clutch is engaged but the clutch quickly quits and just blows semi cool to warm air. One possible cause of this symptom is that the Thermistor may be defective.

What happens if you lose the blower motor relay?

The blower motor is the component responsible for pushing air through the vents of your vehicle’s heating and air conditioning systems. Without it, the AC system will not be able to circulate any heated or cooled air. The blower motor relay controls the current used to power the blower motor,…

Why is the fan on my Nissan Frontier not working?

Disconnected the motor and brought it into the garage. The fan has a big white fan blade on top and the motor sits in a black plastic case. One philips screw holds the motor in the casing. I carefully pried the motor out of the casing. My fan blade was a bugger to get off. Seized on.

The blower motor is the component responsible for pushing air through the vents of your vehicle’s heating and air conditioning systems. Without it, the AC system will not be able to circulate any heated or cooled air.

What causes a car heater fan to stop working?

Fixing up the ACCS might solve the problem. The motive force for fan functioning is provided by the motor attached to it. A motor failure will obviously may cause the fan failure, causing an overall car heater failure. Fixing the motor should solve the problem in this case.

Where is the heater fuse on a car?

the heater fuse/relay is behind the kick panel on the p/s of the car (kick panel is the panel under the dash and between the door and firewall) also while you are down in that area check to make sure the blower motor is getting voltage aka bad blower motor)

What to do if your Mercedes heater blower is not working?

My blower motor was fixed in with 3 posidrive screws. Had to use a stubby screwdriver on one of them too due to a serious lack of room. Check first before just pulling it out Rooty.

My blower motor was fixed in with 3 posidrive screws. Had to use a stubby screwdriver on one of them too due to a serious lack of room. Check first before just pulling it out Rooty.

the heater fuse/relay is behind the kick panel on the p/s of the car (kick panel is the panel under the dash and between the door and firewall) also while you are down in that area check to make sure the blower motor is getting voltage aka bad blower motor)

Why does the fan switch not turn on?

If there’s no voltage when the fan switch is on, then you’ll need to trace things backward. Either the relay isn’t being energized or the other part of the relay isn’t getting power from the fuse. Does the relay click when the fan is turned on?

What are common reasons my Nissan Maxima has heater problems?

What are common reasons my Nissan Maxima has heater problems? While there are a variety of reasons your Nissan Maxima heater is not working, the most common 3 are a broken heater blower motor, a problem with the thermostat, or a failed heater blower motor resistor. See what others are asking about their Nissan Maxima.

What to do if your Ford Fusion heater is not working?

When the blower motor resistor fails, the air conditioner and heater may still work, but air may blow from the vents at only some of the fan speed settings. If the resistor isn…

What happens when the blower fails on a Chevy Equinox?

When the blower motor fails, the air conditioner and heater may still work, and heat or cool may be felt at the vents, but the air pressure will be dramatically decreased. This Read More When the heater control valve fails, adjusting the temperature may not change the air temperature at the vents, whether hot or cold.

What to look for when your car fan is not working?

Your vehicle should have a complete relay diagram showing the location of all of the vehicle’s electrical components such as fuses and relays. To fix any blower, the first things to look at are the fuses, relays, and electrical connections.

If there’s no voltage when the fan switch is on, then you’ll need to trace things backward. Either the relay isn’t being energized or the other part of the relay isn’t getting power from the fuse. Does the relay click when the fan is turned on?

What should I do if my heater fan doesn’t work?

Replaced 10 amp fuse , blower relay,blower motor,dash s dash switch and switch out under the hood relays. Seems no power to anything when checked with a test light. Blower motor *resistor* been tested? ..

Is the 10 Amp Fuse on my heater fan burned out?

The 10 amp fuse was not burned out. The blower motor resistor was a little rusty.I inspected and found no burned or melted wires anywhere , at the inside three way dash switch , at the blower motor and at the resistor.I know the air bag is tied into the same fuse , I must have replaced the fuse 12 times .

Why does my blower fan not keep working?

There’s a switch or something located under the blower fan that goes bad, and not all the fan speeds will keep working. Like on mine, the lowest fan speed no longer works, but the rest do. That’s the blower resistor.

What happens if a heater blower has no power?

A blower motor without power will not be able to produce any air pressure, and as a result the heating and air conditioning system will be left with no air coming from the vents.

Can a broken motor switch stop a blower?

A broken blower motor switch can also stop the blower from changing to certain speed settings. If your blower motor cannot change to certain speeds, check both the resistor and the switch on your dashboard. The most common failure points are the resistor and the motor itself.

When to replace a blower resistor on a car?

If the fan operates at some speed settings, but doesn’t work at some other speed settings, this means that the blower resistor is faulty and should be replaced: Find the blower resistor and detach it from the rest of the circuit. For the precise location, consult the repair manual for your car’s make and model.

Why is my heater blower motor resistor not working?

This occurs due to the failed blower motor resistor not being able to control the flow of electric current, it could be that the resistor is somehow bypassed and the power is directly being fed from the switch. Excessive current can overheat and permanently damage the blower motor resistor

Where is the motor for the heater blower located?

The motor that turns the blower is called the blower motor. It is located in the dashboard, usually on the opposite side of the steering wheel or inside the engine compartment on the firewall. The blower speed can be adjusted in almost every modern car.

Where do I replace the resistor on my blower motor?

To repair the problem, simply replace the resistor block. It’s usually located in the ductwork (to keep the coils cool) below the glove box. Unplug the electrical connector, remove the screws and replace the unit. Replacement blower motor resistor blocks are usually available from any auto parts store or the dealer.

What to do if your blower motor only works on high speed?

If your blower only operates on its highest speed, chances are you have the series type of blower motor resistor. This is the most common failure mode. To repair the problem, simply replace the resistor block. It’s usually located in the ductwork (to keep the coils cool) below the glove box.

Why is my car heater not working properly?

The most common cause of any problem is a blown fuse. This is normally in the main fusebox although it may be an in-line fuse wired into the feed of the motor itself. Check in your workshop manual to find the exact position of the fuse.

What to do when your electric heater won’t work?

Probe the fuse output terminal with the lamp. If the lamp fails to light, change the fuse and try again. If the lamp lights but the heater still won’t work, then the wiring between fusebox and switch is faulty. If you can find no fault with the wiring, use a test lamp to find out if there is a feed to the motor.

What to do when your heater fan stops working?

Fuse Good Relay (fan speed under hood) on firewall replaced Still no power getting to blower motor (purple wire) Mechanic found the harness plugging into the fan switch in the dash had melted. Unplug and take a look at yours. A.C. and heat blower now work. I was surprised the meltdown in harness dident blow any fuses 3 people found this helpful.

Why is my electric heater not turning on?

CAUSE: The first and most common cause for electric heater not working or turning on is problem with the power supply. SOLUTION: You need to make sure that power is available from the main supply. If yes, then check whether the power switch is working properly or not.

Why does my air conditioner fan stop working?

Like the circuit breakers in your house, these fuses are designed to break the electrical connection when too much electricity causes your fan to overheat. When the fuse melts, it breaks the connection and cuts power to the fan.

Fixing up the ACCS might solve the problem. The motive force for fan functioning is provided by the motor attached to it. A motor failure will obviously may cause the fan failure, causing an overall car heater failure. Fixing the motor should solve the problem in this case.

What to do when your AC Fan is not working?

Checked for incoming resistance ground to the blower, from the dash control switch and it works. Checked for battery at the blower, when the car is running. There is no battery to operate the blower. Rotated all the PDC relays around, they have the same ID, other than ABS pump.

Your vehicle should have a complete relay diagram showing the location of all of the vehicle’s electrical components such as fuses and relays. To fix any blower, the first things to look at are the fuses, relays, and electrical connections.

How does a blower motor resistor control the fan speed?

The blower motor resistor controls the fan speed of the blower motor and the resulting change in air pressure produced by the movement of the blower fan. It accomplishes this by regulating the electric current that powers the motor.

Posted In Q&A