Why did my 2004 Duramax engine not start?

Why did my 2004 Duramax engine not start?

My 2004 Duramax started and then died like it was out of fuel. Now it won’t start. I have about 1/4 tank of fuel, tried priming it until the batteries died.

Why is my Duramax not starting after fuel filter change?

Changed the fuel filter today, and cannot for the life of me get the system primed back up. I loosened the bleeder screw, and have been pumping for so long that there’s a blister on my hand.

What causes a Duramax injection pump to fail?

As a result (allegedly), the lack of lubrication in the fuel can cause a premature failure of the injection pump, to a point where it won’t allow the LML Duramax to run. You can be driving down the road and everything seems normal, and when the pump fails, the truck just shuts off.

Why does my 04 LB7 engine not start?

Now engine wont start anymore. Went to start my 04 LB7 this morning to let it warm up before going to work. As I shut the door and walk away, the engine died. I tried to fire it back up but it just spins over and doesnt start. The truck has 144k, has about 3.5k on new injectors installed by dealer, fuel filter was replaced around the same time.

My 2004 Duramax started and then died like it was out of fuel. Now it won’t start. I have about 1/4 tank of fuel, tried priming it until the batteries died.

Changed the fuel filter today, and cannot for the life of me get the system primed back up. I loosened the bleeder screw, and have been pumping for so long that there’s a blister on my hand.

What kind of engine cranks but won’t start?

Filled tank today, was 3/4 full. Drove home 5 miles. came out several hours later, engine cranks normally but won’t fire. Held throttle down and it started. Had slight surging. Very slight.

What kind of engine does a GMC Duramax have?

I have a 2021 GMC Sierra 1500 AT4 with the 3.0 Duramax that is 4 weeks old with 2500 miles. The following has happened three times. I press the brake, press the start button, the engine turns over for approximately 10 seconds without starting. Each of the three times it has started on the next attempt.

Are there any flaws in the Cummins Duramax?

Still, and just as we exposed the shortcomings of the almighty Cummins, the Duramax isn’t without its flaws—some of them catastrophic. For example, did you know the injection pump on the LML version is prone to coming apart and wrecking the entire high-pressure fuel system when it does?

When did the first Duramax V8 engine come out?

Duramax Engine LB7 2001 to 2004 The first Duramax V8 was introduced in 2001 and was given the code name LB7. The introduction of common rail injection powered by the Bosch CP3 injection pump made the LB7 Duramax stand apart from other diesels of the day with excellent power and efficiency.

Are there any problems with the GM Duramax?

In stock form and even when substantially modified, GM’s legendary V8 diesel can provide hundreds of thousands of miles of trouble-free use. Still, and just as we exposed the shortcomings of the almighty Cummins, the Duramax isn’t without its flaws—some of them catastrophic.

What was the code name for the Duramax in 2011?

In an effort to keep up with the ever-tightening emission regulations, GM redesigned its Duramax for the 2011 model year, and this time the code name was LML.

Why does my GMC Duramax not shift at all?

It is saying “service brake system” on the cluster and the abs and brake light is on. It has started doing all of this at the same time. Bump. Anyone have any ideas? I’m going to get an nsbu switch tomorrow and see if that will fix it. Do these sounds like symptoms of the nsbu switch?

Why is the Speedo not working on my Duramax?

Speedo isn’t working and the service Brake system light is on along with the parking brake indicator and the abs lamp. Still isn’t showing the gear indicator. What other speed sensors does this truck have?

When does a GMC Truck shut off when in gear?

Chevrolet- GMC Truck Shuts Off When In Gear. After the motor heats up when i put the truck in drive. It also shut off when i put in reverse. The Chevy truck stalls . Sometimes the truck shuts off but mostly when i put the Chevrolet in drive it shuts off.sometimes it shuts off when i put the truck in gear. GMC Truck Shuts Off When In Gear.

Is there a 2004 GMC 2500HD with no fuel pump?

Recently purchased a 2004 GMC 2500HD, 84000 miles on it. Ran like a champ from June to November.. The minute the cold rainy weather came, have now had 5 times the truck completely dead, no start, no click, no fuel pump, Nothing.

Why does my GMC Silverado have no crank?

This is a fix for a known electrical issue with the 2003-2007 C/K series GM Trucks where a bad ground causes multiple issues. Such as no start, no crank, intermittent no gauges, and sometimes the theft light would stay on, and the parking lights would stay on.

When does a Silverado 2500HD won’t start?

Ran like a champ from June to November.. The minute the cold rainy weather came, have now had 5 times the truck completely dead, no start, no click, no fuel pump, Nothing. Couple of times, turn the key, put the truck in drive, back in to park, turn the key off, turn the key back on, truck starts up.

Are there any problems with the Duramax LB7 diesel?

Since the LB7 is a bit behind the performance curve compared to more modern diesel engines, performance modifications are common. Once you reach the 550rwhp mark, the LB7 is very prone to bending rods and also snapping crankshafts. Additionally, more power requires more fueling and more cooling.

Why is my Duramax LB7 engine overheating?

The second potential cause of overheating on the LB7 is a dirty radiator. Naturally over time the radiator will pick up gunk, dirt, and various other particulates. As this happens, the effectiveness of the radiator decreases which can then result in overheating as well.

Recently purchased a 2004 GMC 2500HD, 84000 miles on it. Ran like a champ from June to November.. The minute the cold rainy weather came, have now had 5 times the truck completely dead, no start, no click, no fuel pump, Nothing.

What causes a Duramax diesel engine to heat up?

When the engine is working hard, the turbocharger is drawing in a ton of air, and the restrictive stock turbo inlet tube can effectively choke the VGT turbocharger causing the compressor outlet temperature to skyrocket, heating up the intercooler, and ultimately raising the temperature of combustion and the coolant temp.

Are there any problems with the LLY Duramax?

In terms of LLY injector problems, GM had sorted out the internal failures with the 2004 ½ redesign, but the LLY Duramax would occasionally exhibit a trouble code for the injectors, but in most cases it turned out to be an issue with the injector harness rubbing through and causing a short or open in the wiring.

As a result (allegedly), the lack of lubrication in the fuel can cause a premature failure of the injection pump, to a point where it won’t allow the LML Duramax to run. You can be driving down the road and everything seems normal, and when the pump fails, the truck just shuts off.

Why does my Duramax say reduced engine power?

If you’ve got a Duramax diesel, the Reduced Engine Power warning could Illuminate for a variety of reasons. There are many different technical service bulletins (TSBs) for Duramax-powered vehicles that mention Engine Reduced Power mode.

Why does my GM car say no start no crank?

How to diagnose a no start no click on GM vehicle. If you have a late model GM vehicle and turn the key only to hear nothing, you’ll most likely think you have a dead battery—and you may. But a no start, no crank, no click condition can be far more involved than that.

Why does my car starter not turn on?

Doesn’t take much juice to click the solenoid, but it takes a lot of juice to turn the starter and turn over the engine. The other thing is it is an intermittent problem on the vehicle, so if the starter was intermittently acting up when installed, it could also be intermittently acting up when tested at the auto parts store.

Why does my starter click when I turn the key?

It sounds like power is getting to the starter because I can hear a loud click when I turn the key. I’ve researched the topic thoroughly on this site but no one has seemed to have the same problem. In all the other cases there is click coming from the starter. Any help greatly appreciated. Thanks

Still, and just as we exposed the shortcomings of the almighty Cummins, the Duramax isn’t without its flaws—some of them catastrophic. For example, did you know the injection pump on the LML version is prone to coming apart and wrecking the entire high-pressure fuel system when it does?

How can I Keep my Duramax Diesel pump healthy?

However, there are measures you can take to keep the pump happy and healthy, the first being to always buy your diesel from a high-traffic, reputable filling station that’s known to dispense good, clean fuel. Second, always change the fuel filter at or before the recommended service interval.

What to do if your Duramax crankshaft is weak?

The ultimate fix for the weak factory crankshaft is to replace it with a stronger unit that’s been internally balanced. The billet Callies crankshaft available through Wagler Competition Products is machined from triple heat treated 4330V steel and features reduced rod journal widths for improved strength (which calls for narrower rods).

Why does my Silverado 2500HD not start up?

No power to the pump. No click of the starter, absolutely no sound of anything starting up at all. Delay has replaced the fuel pump relays, works for a day or two, then go to start it, nothing again. No crank from the starter, no sound of the fuel pump, but power to the dash lights.

What to do if your truck won’t start?

The minute the cold rainy weather came, have now had 5 times the truck completely dead, no start, no click, no fuel pump, Nothing. Couple of times, turn the key, put the truck in drive, back in to park, turn the key off, turn the key back on, truck starts up. Last two times, Completely dead, nothing to get it started.

No power to the pump. No click of the starter, absolutely no sound of anything starting up at all. Delay has replaced the fuel pump relays, works for a day or two, then go to start it, nothing again. No crank from the starter, no sound of the fuel pump, but power to the dash lights.

The minute the cold rainy weather came, have now had 5 times the truck completely dead, no start, no click, no fuel pump, Nothing. Couple of times, turn the key, put the truck in drive, back in to park, turn the key off, turn the key back on, truck starts up. Last two times, Completely dead, nothing to get it started.

Posted In Q&A