Why is my instrument cluster not working on my Freightliner?

Why is my instrument cluster not working on my Freightliner?

With the the ignition switch turned on (engine not running) the instrument panel should be active. The fact the the engine started, indicates that the 30 amp engine fuse is good. You posted that the cluster fuses where both good. That could indicate a defective ground or a Defective Display.

Where is the test light on a Freightliner?

It can be found with your fuse panel. With the key on take a test light ground it and check for 12 volt power at the solenoid. There should be two cables on the solenoid.

What does no gauge sweep mean on a truck?

The no gauge sweep is the puzzler. When you are getting no power to the starter solenoid and the ECM is not doing it’s self diagnostics I would think it was the ignition switch. But you could have two separate problems which in case the posts above are highly possible.

What to do if your Freightliner dash is dead?

Back lights work and turn signal lights work, other than that the dash is dead…….help! What you have is a bad solenoid. It can be found with your fuse panel. With the key on take a test light ground it and check for 12 volt power at the solenoid. There should be two cables on the solenoid.

What kind of equipment does a 1998 Freightliner have?

Has not been abused or neglected VIN-1FV6HFAA7WH892257 83,399 Miles Cummins Turbo Diesel AC AM/FM Air Brakes 6 Speed Manual Transmission Air Ride Seat GVW… 1998 Freightliner FL70 W/Dump Body and Fisher Plow Fisher Snow plow system Dump Body w/tarp Tool Box in between cab and body Heavy Duty Pintle hooks Ready to GO!

What kind of oil gauge does a Freightliner use?

Freightliner Transmission Oil Temperature Gauge A22-71988-002 Removed from 2020 Cascadia 125BBC VIN 3AKJHHDR7LSLA4670 Freightliner E-Cascadia Gauge Cluster A22-75412-001. Freightliner E-Cascadia Gauge Cluster A22-75412-001. FREIGHTLINER PLUG- DASH, GAUGE, 2 1/2 DIAMETER, FITS 2 1/16 GAUGE HOLE, NEW SURPLUS, MAY HAVE SLIGHT BLEMISH DUE TO STORAGE.

What are the gauges on a Freightliner Cascadia?

Freightliner Cascadia P4, 6 Gauge Instrument Cluster with Digital Display A22-75412-101. Freightliner Cascadia P4, 6 Gauge Instrument Cluster with Digital Display A22-75412-101. Freightliner Cascadia P4 ICUC Gauge Cluster A22-75412-000. Freightliner Cascadia P4 ICUC Gauge Cluster A22-75412-000.

How can I tell if my Freightliner solenoid is defective?

What you have is a bad solenoid. It can be found with your fuse panel. With the key on take a test light ground it and check for 12 volt power at the solenoid. There should be two cables on the solenoid. You should have 12 volts on both sides of the solenoid if not then your solenoid is defective.

Where can I buy a Freightliner dashboard panel?

Show details Only 20 left in stock – order soon. Ships from and sold by NIUPARTS. In Stock. FREE Shipping on orders over $25.00. Details In Stock. FREE Shipping.

What’s the model number of a Freightliner Century?

This fits your . Make sure this fits by entering your model number. Fit: 1997-2014 Freightliner Columbia, 1997-2010 Freightliner Century, 2002-2009 Freightliner Coronado Trucks These items are shipped from and sold by different sellers. Show details Only 20 left in stock – order soon.

Why is my Cascadia dash cluster not working?

Discussion in ‘ Freightliner Forum ‘ started by habfleet, Oct 13, 2017 . Have a 2013 Cascadia Isx/15 . Dash worked fine last night went to pull out of shop this AM all gauges not working no display of milage . I have extra gauges swap them out nothing.None of the gauges will sweep upon key on.

When does a Freightliner classic no data link alert come on?

I have a 2005 Freightliner Classic w/14L Detroit 60 Series, 10 spd Ultrashift. I get a “No Data Link” alert after the truck is washed even when the hood is kept closed. When I get the alert the Tach, speedo, oil press, coolant temp, and voltage gages all are dead.

What is the second data stream on a Freightliner truck?

The second data stream is the J1587/J1708 which runs the smart guages, ABS, HVAC, and satellite systems. First this issue showed up only after getting a wash at a truck wash like Blue Beacon, it would last for 10 minutes or so then everything would come back online and never set any fault codes.

When to give Freightliner a call with your Vin?

Let us know if that solves your problem. Give Freightliner a call with your VIN. Thanks to both of you, I’ll call Freightliner on Monday. Mark, you can call Freightliner 24/7/365. O’ great thanks!

Where are the brake lights on a Freightliner M2 106?

Located on the frame crossmember just forward of the rear axle. When looking at it, it will be the switch to the right (driver side) of the cluster, have air lines in and out and a 6 pin harness going into it. Please save yourself expensive repair bills and time to trace wires, locate fuses/relays, multiplexing… yada yada.

Why are the brake lights on my Freightliner not working?

Brake lights not working narrowed it down to the AMU. Problem fixed got home doing a walk around on the truck and noticed something hanging a couple of inches from the driveshaft. Turns out it was the complete block where the AMU sensor is located with all the air lines.

When to go to Freightliner for electrical problems?

I always recommend to customers with weird electrical problems like this or something specific to your make of truck to always always always go to dealer that specializes and sells that make. The techs at Freightliner will have the most experience and the best wire diagrams and information over any other dealer.

What causes a Freightliner Columbia engine to quit?

You many have a fault with one of these or wiring with the datalink. If the engine is quitting that tells me a loss of ignition power or unswitched battery power. The main power to the cab could be lose or corroded at the firewall or where ever it enters.

What kind of engine does a Freightliner have?

After a couple of weeks of inactivity, I thought it best to fire up the engine on my 2004 Itasca Horizon (Freightliner Chassis/Cummins 350HP diesel) although it fired right up, I realized none of the normal buzzers and lights preceded me…..low and behold every gauge and idiot light was flatlined!

What do the lights mean on a Freightliner?

The MC has a built in Diagnostic Function that indicates whether or not the MC is receiving DATA from the Vehicle Data Computer (VDC) If the data is not received from the VDC for more then 45 seconds, the Icon lights will “Dance” or initiate a chase pattern. With out an indication of the test program, could indicate a defective panel?

Where is the VDC located on a Freightliner?

When you mention a Module, are they talking about the VDC (vehicle data computer). It is an interface between the ECM and the Instrument cluster. The VDC is shock mounted on rubber feet. One in each corner. Have they informed you of what is missing ?

Where is the PDM on a Freightliner M2?

The fuse panel is located below and to . The main fuse box, also known as the power distribution module, or PDM, is located under the hood onthe left front fender just forward of the bulkhead module. View and Download Freightliner BUSINESS CLASS M2 driver manual online.

Where is the fuse box on a Freightliner M2?

The main fuse box, also known as the power distribution module, or PDM, is located under the hood onthe left front fender just forward of the bulkhead module. View and Download Freightliner BUSINESS CLASS M2 driver manual online.

Is the speedometer on my Freightliner not working?

The speedometer & odometer are not working. I hooked my prolink to it & do not get a Freightliner..The speedometer & odometer are not working… I have a 2003 freightliner with a 500 Cummins/10 speed that gets a true 6 mpg.

Posted In Q&A