How do you replace a sliding door cable on a Toyota Sienna?
Without further ado, here’s how you can replace the side door cable assembly in your Sienna: Take out the seat closest to the defective sliding door. (Optional; this just gives you more room to work on the door.) Roll down the window on the defective door. On the side of the door is a hex screw holding the plastic panel in place.
How do you replace a sliding door cable?
Remove the nut holding the cable in the bracket and then slide the cable assembly out of the bracket. Inside the door, there are three bolts holding the cable assembly in place (where the cable makes a right angle turn). Remove all three bolts. Under the arm that connects the door to the van body are two more bolts. Remove them both.
When is sliding door assembly replacement service available?
Fast and easy Sliding Door Motor Assembly Replacement service at your home or office. How can we help? Our service team is available 7 days a week, Monday – Friday from 6 AM to 5 PM PST, Saturday – Sunday 7 AM – 4 PM PST.
When does a sliding door motor wear out?
The sliding door motor receives power from the body control module when the input signal occurs and stays powered up until the door reaches its limit. If the sliding door motor assembly is used excessively, it can wear out. If the sliding door motor assembly stops working, you may have trouble opening the door by hand.
Without further ado, here’s how you can replace the side door cable assembly in your Sienna: Take out the seat closest to the defective sliding door. (Optional; this just gives you more room to work on the door.) Roll down the window on the defective door. On the side of the door is a hex screw holding the plastic panel in place.
Where is the release actuator on a Sienna?
There’s a pulley system with a Sienna side door release actuator in the bottom corner of the door. (If you’re working on the right door, the pulley system is in the bottom right corner; on the left door, the pulley system is on the bottom left corner.) Remove all of the screws holding it in place. Slide-out the side door cable assembly.
Remove the nut holding the cable in the bracket and then slide the cable assembly out of the bracket. Inside the door, there are three bolts holding the cable assembly in place (where the cable makes a right angle turn). Remove all three bolts. Under the arm that connects the door to the van body are two more bolts. Remove them both.
When did power sliding door on Toyota Sienna Le stop working?
In 2014, the driver’s side power sliding door cable snapped on our 2009 Toyota Sienna LE with about 150,000km. It stopped working and you could see a rusted cable hanging outside of the third row window.
What does CSP stand for in Toyota Sienna?
It is a Customer Support Program (CSP) extended warranty meant to enhance Sienna ownership experience and satisfaction. It covers the power sliding door latch assembly and/or the power sliding door cable assembly on certain model Sienna’s.
Why is the sliding door on my Sienna XLE not working?
It would only work when I pulled the handle. Here is a breakdown of the symptoms I was having with my 2004 Toyota Sienna XLE: All of this is pointing to the motor inside the door that essentially “pulls the handle” for you when you remotely open the door.
What’s the name of the sliding door on a Sienna?
(Playback ID: zpBDlbdDS0SWKmL6) An error occurred while retrieving sharing information. Please try again later.
Can you replace the tailgate handle on a Toyota Sienna?
T1A Exterior Tailgate Handle Replacement for 1998-2003 Toyota Sienna, Also Fits 2001-2007 Toyota Sequoia, All Metal, T1A-69090-08010 . . . . Dealer Sales Solutions LLC.
Where can I buy a genuine Toyota door cable?
In Stock. Ships from and sold by Santa Margarita Toyota. In stock on February 23, 2021. Order it now. Sold by Amazing Parts Warehouse and ships from Amazon Fulfillment. FREE Shipping on orders over $25.00. Details In Stock. Sold by Volay and ships from Amazon Fulfillment. FREE Shipping on orders over $25.00. Details
Is the driver side slider on a Toyota Sienna?
Hi, I’m new to the forum and a relatively new used Sienna owner. I have an ’08 Limited that I got off the used car lot. I replaced the battery after getting it home and lost function of the driver side slider.
How to fix a Toyota Sienna power door problem?
1. Disconnect the battery 2. Push and hold the door open button for 10 seconds (Dash or door buttons) 3. Now, this is key, open and close BOTH doors manually. 4. Wait 5 minutes then reconnect the battery. Not 3 minutes, not 4 minutes, but 5 minutes. This should do it. BTW, I have a door ECU if anyone wants it. $50.
Where is the power switch on a Toyota Sienna?
The 2nd Generation power switch is located to the left of the steering wheel, on the lower portion of the dashboard near the driver’s left knee. You can conceivably turn the power “off” and use the door manually all of the time, or as needed.
Why is the sliding door on my Toyota Sienna not working?
Sliding Door Latch Failure: The sliding door in in this generation of Sienna minivans comes with a latch that doesn’t always do its job. This causes the door to not open when commanded and triggers the door to open at unexpected times, including while the van is in motion.
Are there any problems with the Toyota Sienna?
Many Sienna owners successfully resolve this issue by replacing it with an OEM metal cooler pipe (Part No. 15767-31020 ). Shift Lock Solenoid Failure: The shift lock solenoid in 2004-2009 Siennas is prone to failure, which allows the driver to move the shift lever out of the park position without depressing the brake pedal.
What causes Toyota Sienna to roll out of Park?
Shift Lock Solenoid Failure: The shift lock solenoid in 2004-2009 Siennas is prone to failure, which allows the driver to move the shift lever out of the park position without depressing the brake pedal. This causes the minivan to unexpectedly roll out of position.
Why is my side door on my Sienna not opening?
We can think of a few common reasons: 1 Latch Motor Failure Sometimes the side door will struggle to open when you press the button to automatically open it. 2 Frayed Cable The cable in the side door is prone to fraying and then breaking. At first, the door won’t work properly. 3 Circuit Overload
How do you remove a defective car door?
Roll down the window on the defective door. On the side of the door is a hex screw holding the plastic panel in place. Remove the screw. Slide the lock back into the door, in the unlock position. (This prevents the lock from coming out when you remove the plastic panel.) Gently pry off the plastic panel.
Can a broken fuel door cause a sliding door to break?
Period. If the sliding door broke because of a fuel door then of course they are both covered. All problems with the fuel door including the common broken hinge problems are also covered under the service campaign at no cost.
How much does a Toyota Sienna sliding door cost?
The average cost for a Toyota Sienna General Diagnosis is between $88 -$111. Learn More My electric sliding door only works if you start it off manually. If I pull on the handle it will close or open the door from the outside but not with the electronic buttons.
Why is my Toyota Sienna door not opening?
My 2004 Toyota Sienna’s door would not open or close when I used the remote or the inside buttons. It would only work when I pulled the handle. Here is a breakdown of the symptoms I was having with my 2004 Toyota Sienna XLE:
Is there a power door switch on a Toyota Sienna?
I’m not familiar with the 2002 (1st Generation) Sienna, but in the 2004 (2nd Generation) Sienna, there is an “on/off” switch that controls the power to the power doors (if so equipped). This power switch is different and separate from the button (s) that open (s)/close (s) the door.
How long is the Toyota Sienna power sliding door warranty?
2) Power Sliding Door Cable Assembly – For certain 2004-2007MY Sienna vehicles equipped with a Power Sliding Door, the warranty coverage for the Power Sliding Door Cable Assembly will be extended to 9 years from the date-of-first-use or 120,000 miles (whichever occurs first).
Is there a recall on the Toyota Sienna?
Toyota has received reports of customer concerns regarding rear sliding doors that gradually become difficult to open or close in certain 2004-2010 model year Sienna vehicles. This is not a Recall, it is a Warranty Enhancement.
When did the Toyota Sienna front wheel drive come out?
First generation (XL10; 1997–2002) In late 1997, Toyota launched the front wheel drive MY 1998 Sienna in the North American market as a replacement for the mid-engined Previa.
Where was the Toyota Sienna built in Kentucky?
The driver side sliding door and roof rack were standard on the LE and XLE models, but were optional on the CE models. The XLE models offered leather seats and a wood trim package. The Sienna also touted best-in-class fuel economy of 16 city/22 highway miles per gallon. It was built in Georgetown, Kentucky.
What to do when your Toyota Sienna side door won’t open?
A common complaint among Toyota Sienna owners is that their Sienna side door won’t open or close. If you’re experiencing a stuck Sienna side door, you came to the right place. This guide covers all the information you need to navigate this issue like a pro.
Why is my Toyota Sienna power sliding door not working?
You are probably here because you opened your 2004-2010 Toyota Sienna’s power sliding door and heard a pop and some crunching noise inside the door and now the door will not automatically open. You’ve come to the right place. Don’t throw $1,000+ down the drain at a dealership–fix this yourself!
How to replace power sliding door cables on 2004-2010?
[I] have a 2004 XLE… driver side cable-spool finally jammed/broke as they all do. At that time, followed your instructions, but bought the cable only repair part for around $200. I wound the spool successfully, and it’s not that hard to.
When did the left door on my Sienna van break?
The left door on our 2010 Sienna van broke a few months back and I took it to the dealer and spent $1500.. when the right door broke I decided to do the repair myself.. and I am glad that I did… –John Hi, I can’t thank you enough for this detailed article!
How do you open the doors on a Toyota Sienna?
Simply use a quick kicking motion with your foot to open and close Sienna’s available kick-activated 87 dual power sliding doors and rear liftgate 100 to make getting in and out easier.
What kind of interior does Toyota Sienna have?
On road trips or campouts, passengers can watch their favorite shows in the back with Sienna’s available 1080p HD Rear-Seat Entertainment Center. Platinum interior shown in Noble Brown leather trim. Prototype vehicle shown with options using visual effects.
Which is the best trim level for Toyota Sienna?
To help you make a decision, the product experts at Advantage Toyota of River Oaks crafted this 2020 Sienna trim level comparison guide. We provide a variety of competitive offers for drivers to take advantage of.
What kind of plug broke on my Toyota Tacoma?
Broke 5/6 on wife’s Lexus and 4/6 on my Tacoma when doing 1st plug change – at 100K for the Lexus and 50K for the Tacoma. Have repaired none of them and none have come loose.
What should I do if my throttle cable snapped?
The most likely way that should work for you is finding the broken part of the cable (that is still attached to the carb) and using your hand to pull open and closed the throttle. If the cable end snapped, you can tie a shoelace around the carb throttle and pull it that way.
Is the coil plug on my Toyota Camry broken?
Hey guys, I just replaced the spark plugs in my wife’s 2009 camry. When I was disconnecting the coil connectors from the boots, the little plastic clip holding the connector on the boot would snap right off.
Where can I buy a genuine Toyota Sienna?
Keep it Toyota. Shop Toyota USA’s dealer network for Genuine Toyota Sienna Body and Interior Parts & Accessories.
What to do when your side door won’t open?
The only way you can get the door open is to pull the handle and then hold it for two or three seconds. This happens when the latch motor fails, which is fairly common in Toyota Siennas.
Are there any problems with my Toyota Sienna sliding doors?
We are having problems with our Toyota Sienna 2006 sliding doors. They never worked properly since we bought the vehicle. They were repaired in 2007 but never really worked properly and now they are frozen. The warranty has expired.
Where is the button on the side of the sliding door?
Note: At some point you will either want to disconnect the positive battery terminal from your battery or simply put the sliding doors in manual mode so you can manually open and close your sliding door as needed to complete the repair. The button to put the sliding doors in manual mode is located at the left knee of the driver: