Why is my air conditioner not working on my 2004 golf?
2004 vw golf air conditioner compressor does not engage. there is no power to the electro-magnet. Is there a relay? any 2004 vw golf air conditioner compressor does not engage.
What’s the temperature on a VW Golf air conditioner?
Disconnect the 14 pin connector and verify continuity between pin T14/14 (Green/Blue) and T14/5 (Blue/Red). This checks the Ambient Temperature Switch (ATS) (normal open circuit below 32 degrees F, continuity above 32 degrees F).
What to do if your VW compressor is not working?
VW AC COMPRESSOR FIX CHEAP! VW A/C COMPRESSOR NOT WORKING – YouTube If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations.
What’s the duty cycle on a Volkswagen a / C compressor?
3. Verify an approximate 70% duty cycle from the A/C pressure sensor at pin T14/2 (white) with the ignition on and the compressor not running (duty cycle will decrease as the high-side pressure increases).
What to do if your a / C compressor is not working?
Using a fused 12-volt jumper, apply power to pin T14/10 (green/black). The compressor clutch should engage. If the compressor does not engage, check for a wiring harness open circuit or loss of ground at the compressor. Reconnect the 14-pin connector.
What causes a VW Beetle compressor to not engage?
As the terminals corrode, the fuse box develops excessive resistance and heat that can burn up the plastic frame, also resulting in a burned compressor clutch fuse, wire or simply a compressor clutch won’t engage condition. The problem fuse bracket can be found on all 2001-05 VW Beetle vehicles
What to do if your air conditioner compressor does not engage?
Disconnect the 14 pin connector. Using a fused 12 volt jumper, apply power to pin T14/10 (Green/Black). The compressor clutch should engage. If the compressor does not engage, check for wiring harness open circuit or loss of ground at the compressor. Reconnect the 14 pin connector. 10.
Why does my AC compressor clutch not engage?
Why AC clutch won’t engage If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways.
Why is my Volkswagen Golf blowing hot air?
When the air conditioner in your 2003 Volkswagen Golf starts blowing hot air, you likely have a freon leak. Recharging the freon in your AC system is an inexpensive and easy first step to restoring the cooling capacity of your A/C system.
Why does my VW Mk4 AC compressor not kick on?
Common problem for VW mk4 AC compressor to not kick on… Dead radiator fans. If you turn the key and turn on AC, both radiator fans should come on. If not, AC compressor will not engage, and most likely one fan is dead. Replaced with $40 for both off ebay… And I have AC. Loading…
Where is the fan control module on a VW Golf?
The fan control module is located under the radiator and has 2 connectors; a 14 pin (T14) and a 4 pin (T4). 2. Check for 12 volts to pin T4a/1 (Red/Black) and T4a/3 (Red) via fuses S164 and S180 respectively, in fuse box on top of battery, at all times.