Why does my Detroit 60 truck not start?
No matter how much fuel in the tanks or no specific time before it will not start. I have tried to figure a pattern but it is just to random and often. Truck exibits no problems while I drive it.
What to do if your Detroit Diesel engine wont start?
Using a starting fluid should help combat this issue, and you shouldn’t have any other problems from it once the engine is running. Changing the SRS (Synchronous Reference Sensor) and TRS (Timing Reference Sensor) could also help with this issue. These two sensors should be replaced at the same time to maintain proper operation.
Are there any problems with Detroit Diesel Series 60 engines?
Changing the SRS (Synchronous Reference Sensor) and TRS (Timing Reference Sensor) could also help with this issue. These two sensors should be replaced at the same time to maintain proper operation. This particular issue affects Series 60 engines built before 2002.
What was the 2000 Series 60 Detroit that won’t start?
2000 series 60 detroit that… Submitted: 10 years ago. Category: Heavy Equipment Yes it turns over and no smoke its like the ecm just isn’t sending signal to injectors to fire Hi and welcome to JA. I am Buddy, and i will try and help you out.Sorry for the long reply time.Your question was somehow in the wrong catagory.
What kind of truck engine will not start?
I have a 2000 FLD 120 Freightliner with the Detroit series 60 engine. Lately It will just spin over at normal rpm but will not start until I give it a bit of ether.
Why are my Detroit Diesel Series 60 brakes not working?
These brakes could require different programming than what is standard on the Series 60, and the disconnect could cause a loss of throttle. If this is not the issue and you’re still experiencing throttle issues, you’ll probably want to take a look at your TPS (throttle position sensor).
How to troubleshoot a Detroit Diesel Series 60?
Check the air inlet and exhaust restrictions. Visually inspect the air intake and exhaust system for restrictions; if found, repair as necessary and verify repairs. If no damage is found, go to No RPM Data Received via DDDL 7.0, refer to “4.14.2 No RPM Data Received via DDDL 7.0” .
How can I crank my engine without starting the engine?
This allows cranking without starting the engine. Attach a long jumper lead from the battery negative post to the negative lead of the voltmeter. Connect the positive lead of the voltmeter to the three locations listed below, measuring voltage at each point, one at a time while the starter is cranking.
Are there any problems with the Detroit Series 60?
This issue did not affect all pre-2002 Series 60 engines, but it was a problem that occurred and could cause catastrophic engine failure. As with most engines, it’s a good idea to keep an eye on your cooling system. Overheating is the cause of many major issues with diesel engines, so maintaining this system can help with many preventable issues.
What causes a Detroit Diesel Series 60 to spin?
If there’s an issue with your throttle, that’s a good place to start. Bearing problems, particularly spun bearings, are typically caused on older Series 60 by low oil pressure at idle. A spun bearing occurs when there is a lack of lubrication causing overheating. The bearing can eventually seize, creating even more problems.
What to do if your Series 60 engine is not working?
If this is not the issue and you’re still experiencing throttle issues, you’ll probably want to take a look at your TPS (throttle position sensor). This sensor works with the electronic control system in drive-by-wire applications like the Series 60 engines, allowing for the electronic control to occur.
Why does my truck randomly do not start?
No matter how much fuel in the tanks or no specific time before it will not start. I have tried to figure a pattern but it is just to random and often. Truck exibits no problems while I drive it. I am planning to take it to Freightliner Thursday. Just thought you folks might have an idea on this.
What happens when the fuel line goes bad?
Sometimes have to wait for a load If you have the clear glass davco type fuel filter it also has a ck. valve on fuel line that goes bad, all it takes is a small bit of trash in ck. valve to make it louse prime . Is there something that I should know about priming the system and getting all the air out?
What makes a Freightliner classic not build air?
There are backstream valves inside that let first and second tank share air when pressure in one of tanks is lower four bar. Backstream bore was clogged and compressor was off till second tank pressure was lower the compressor actuation point. Changing both the valves solved problem.
What are the air bags on a Freightliner classic?
First – for rear brakes, second – for front brakes, third – for park brake valve and trailer air supply, fourth – for cabine air bags, air controlled transmissin (ZF), clutch servo (if equiped), and all other additional equipnet, like PTO solenoids, fan clutch solenoid and other.
Is the Detroit Diesel Series 60 still in production?
This electronically controlled engine has a favorable history, shared between all three versions, and despite having been out of production for years now, it remains a popular choice for many operators. Even though this engine has been relied on by many for years, it still has its share of issues, like any other would.
What should I do if my engine wont start?
Check / replace fuel return overflow valve. Drain fuel-water seperator or replace fuel filter. Loosen the high pressure line at two injectors and visually check fuel delivery while cranking the engine. Replace injection pump, if fuel is not being delivered. Check the injection pump timing.