How to clean exhaust filter on Chevy Duramax?
It will not totally shut down on you. It will just limit itself to 2000rpms. Go pull your battery cable and leave it disconnected for about a minute. Then reconnect it. It should take it out of limp for a bit unless the soot mass is heavy.
What kind of exhaust filter does a Silverado have?
The 2008 Chevrolet Silverado equipped with the Duramax diesel engine has an inline filter in the exhaust called the diesel particulate filter (DPE). This filter was installed to reduce emissions, but some owners want to remove the filter so that they can gain extra mileage or performance out of the engine.
What kind of exhaust system does a Duramax have?
Straight through wide open, high-flow mufflers, no baffles or chambers, less chance of resonation. (excluding DPF back systems) Tuned to specific vehicle applications for ultimate power when used in conjunction with AFE air intake filters.
Why is my GM truck throwing an exhaust filter error?
GM has a new TSB out that you’ll need to be aware of. Owners of certain 2007-2021 GM vehicles with a diesel engine may sooner or later get an error message declaring “CLEAN EXHAUST FILTER SEE OWNERS MANUAL NOW” or something similar. If so, it’s vitally important you understand why this message is appearing and how to fix it.
The 2008 Chevrolet Silverado equipped with the Duramax diesel engine has an inline filter in the exhaust called the diesel particulate filter (DPE). This filter was installed to reduce emissions, but some owners want to remove the filter so that they can gain extra mileage or performance out of the engine.
Where is the exhaust filter on a Duramax truck?
Put the truck on jack stands with the jack, positioned high enough that you can move freely under the vehicle. Locate the exhaust filter, which is the circular, inline canister on the exhaust. It is located under the middle of the cab.
Can a camper have a clean exhaust filter?
My buddy has a 2007 6.6 Duramax. He was pulling a 20,000# camper. He had pulled the camper for over 1200 miles. At one point his clean exhaust filter warning came on. It went off after a while. It them apeared again and he lost power.
How do you remove an exhaust filter from a Chevy truck?
Remove the exhaust hanger holding the exhaust filter to the chassis with your hands. Unbolt the forward section of the exhaust from the exhaust filter using the 3/8-inch ratchet and socket and an open-end wrench. Lower the exhaust filter out of the exhaust system and roll it out from under the Chevrolet truck.
Why does my exhaust filter need to be cleaned?
Today when leaving work for lunch, the “Cleaning Exhaust Fiter – Continue To Drive” message came on. This is the 3rd time I’ve seen this since I’ve owned the truck.
When does MSG ” clean exhaust filter ” come on?
It says the Duramax booklet when the msg “clean exhaust filter” comes on drive it above 30 mph & until it clears. If you keep driving it in a manner that doesnt allow it to clean properly, the check engine light & “reduced power” msg may/will come on. Just an update.
Can you add 5 gallons to the exhaust filter?
Wait until it gets down to 30% or lower and then add 2.5 gallons. You won’t hurt anything letting it get down to even 10% or below. You cannot however add 5 gallons, unless perhaps you were totally empty. Update! The dealer said the truck had 235% soot level in the dpf and wouldnt go into Regen mode by itself.
It will not totally shut down on you. It will just limit itself to 2000rpms. Go pull your battery cable and leave it disconnected for about a minute. Then reconnect it. It should take it out of limp for a bit unless the soot mass is heavy.
It says the Duramax booklet when the msg “clean exhaust filter” comes on drive it above 30 mph & until it clears. If you keep driving it in a manner that doesnt allow it to clean properly, the check engine light & “reduced power” msg may/will come on. Just an update.
Today when leaving work for lunch, the “Cleaning Exhaust Fiter – Continue To Drive” message came on. This is the 3rd time I’ve seen this since I’ve owned the truck.
Wait until it gets down to 30% or lower and then add 2.5 gallons. You won’t hurt anything letting it get down to even 10% or below. You cannot however add 5 gallons, unless perhaps you were totally empty. Update! The dealer said the truck had 235% soot level in the dpf and wouldnt go into Regen mode by itself.