What happens if the steering lock is jammed on a Volvo P1?
For those with 2004-2008 P1s, upon inserting your key into the ignition, you should hear a click noise as the steer lock recedes and allows you to rotate the steering wheel freely. However, if this lock becomes jammed, the warning message “Turn Steering Try Start Again” will appear on the gauge cluster and the car will not start.
Is there an extended warranty for Volvo steering column lock failure?
Steering column lock failure is not covered under any extended warranties, but Volvo eventually acknowledged this problem and did away with the steering lock on 2009 and later model year Volvo C30 s, Volvo S40 s, Volvo V50 s, and Volvo C70 s.
What should I do if I have steering problem in my Volvo?
While Volvo does not specify an oil change interval, you are highly advised to regularly flush the system or add a filter. Draining. [Tip] If you want to drain the system, loosen the fittings at the steering rack, from the pump & reservoir, let all the fluid drain out, then refill system with Dexron ATF.
How do you remove a steering column lock?
Once all screws and necessary wires have been disconnected, pull the cover panel straight down and remove it from the vehicle. You will now have clear view of the steering column lock. Using the T20 torx driver, remove the screw which holds the column lock in place. Pry out the small black plastic piece, circled in the picture below.
Is there a service manual for a Volvo 245?
Volvo 245 (5-door estate / stationwagon with 4-cylinder redblock or 6-cylinder diesel engine) Using the Volvo service manual isn’t hard: just look for the subject described below (like the engine, bodywork or cooling system) and click on the link to open the service manual for that subject.
What to do when your steering wheel won’t turn?
Sometimes, simply jiggling the steering wheel while re-inserting the key is enough to get the steering lock to recede. However, it’s likely that the problem is with the steering lock motor itself. At this point, there are two options: Tow the vehicle to the dealer for a costly repair or break out your tools for a quick do-it-yourself fix.
Why does my P1 Volvo not start up?
Unfortunately, many P1 Volvo owners have discovered that their cars would not start due to a steering lock failure.
How do you remove a steering column lock on a Volvo?
Rotate the side window defroster duct by 180 degrees. Pry downward and outward on the panel behind the water fall console to remove it. Using the T20 torx driver, remove the single screw under the light switch panel.
What to do if the steering lock pin gets jammed?
The lock pin can either get jammed up or down. Disconnect the electrical wiring clip and gently tap the back of the steering lock device with a rubber mallet to loosen anything which might be stuck. At this point, reconnect the electric plug and attempt starting the car while holding the steering lock.
How much does it cost to install a steering lock?
However, professional installation will be required as the steering lock must be programmed to your VIN by the dealer. Expect to pay over $100 for the steering lock, 1 hour of installation labor, and additional software programming fees.
What are all the warning lights on a Volvo?
They are roughly ordered by importance, which tends to be by color (red, amber, yellow, orange, green, blue, gray), but there are nearly 50 of them so be patient! Models examined include C30, C70, S40, S60, S80, S90, C50, V60, V70, V90, XC40, XC60, XC70, and XC90.