What makes the Duramax LBZ engine so reliable?
Unless you are looking to break the 600rwhp barrier, the Duramax LBZ engine is extremely reliable. The tune-only power capabilities combined with its reliability are what make the LBZ the most sought after Duramax today, nearly 14 years after it stopped production.
Why does my Chevy Duramax not crank up?
So after trouble shooting the ignition by sending power (12v) through the crank fuse and turning the key, found that all wiring is good. Would have to be one of the ignition fuses. Checked all fuses with test light and found 40amp ignition fuse to be bad. Replaced and attempted to start. All working as it should at this time.
Why does my 2005 Chevy 2500 HD not start?
My 2005 Chevy 2500 HD won’t start. Engine won’t turn over with key at all. Batteries are hot. You can take a power probe and shoot 12v to starter solenoid wire and it will crank and run fine. I traced that wire back to the fuse panel under the hood on the driver’s side. There is a CRANK fuse as well as a starter relay in that panel.
Why is my Duramax LBZ engine leaking fluid?
The cooler lines are responsible for circulating transmission coolant to keep the tranny from overheating which is important for reliability and longevity. The lines on the Duramax LBZ have a design fault at the “crimp” to where the crimp isn’t suitable enough to hold onto the line and prevent fluid from leaking.
Why does my GMC Silverado have no crank?
This is a fix for a known electrical issue with the 2003-2007 C/K series GM Trucks where a bad ground causes multiple issues. Such as no start, no crank, intermittent no gauges, and sometimes the theft light would stay on, and the parking lights would stay on.
What makes a Duramax LB7 diesel so special?
The introduction of common rail injection powered by the Bosch CP3 injection pump made the LB7 Duramax stand apart from other diesels of the day with excellent power and efficiency.
Are there any problems with the LLY Duramax?
In terms of LLY injector problems, GM had sorted out the internal failures with the 2004 ½ redesign, but the LLY Duramax would occasionally exhibit a trouble code for the injectors, but in most cases it turned out to be an issue with the injector harness rubbing through and causing a short or open in the wiring.
Why is my Duramax diesel engine not working?
The trucks computer keeps track of how much fuel needs to be added or subtracted from each individual cylinder to make the engine run smoothly, and this value is called the balance rate. If one cylinder is contributing too much or not as much as the rest, the cause is usually a bad injector and the cure is a replacement.